West Fraser lumber. File photo.

West Fraser lumber. File photo.

Worker buried in sawdust in a shavings bin at West Fraser B.C. Sawmill

WorksafeBC said rescue was needed on one occasion as the worker was unable to help themself

A worker at the Chasm Sawmill division of West Fraser was buried to about head or chest depth in a wood shavings bin area and needed to be rescued, according to a WorkSafeBC report.

“A worker performing clean up during maintenance type work inside a bin approximately 50 to 80 feet high, 30 feet wide, was engulfed by sawdust and/or wood shavings type recovery waste product,” according to the report. “The need for rescue did arise and the lone worker was engulfed and unable to self-rescue.”

The incident was not immediately reported to the board and between the time of the worker being buried and the conclusion of the full investigation, work resumed.

“This employer did not immediately undertake a preliminary investigation that identified all the unsafe conditions, acts or procedures as far as possible, in order to ensure that work can be continued or resumed,” according to the report. “Also, according to information provided by the employer, another worker was engulfed; however, that worker managed to self-rescue.”

The report notes that West Fraser failed to ensure adequate protection from entrapment or engulfment, a serious health and/or safety hazard.

The worker who entered the wood shavings recovery type bin, “was not provided with and did not wear a lifeline and harness, and was not continuously tended by a standby person who is equipped for and capable of effecting immediate rescue.”

WorkSafeBC was notified approximately one week later during a routine inspection, according to the report.

“This employer failed to ensure the scene of an accident that is reportable under subsection (1) was not disturbed, to permit investigate, and prevent potential injuries or death, and any other worker(s) being engulfed.”

A preliminary investigation report was completed and provided to a WorkSafeBC officer. West Fraser has since developed and performed a risk assessment, developed a safe work procedure for entering the shavings bin and as of Nov. 21 planned an emergency drill for confined space and/or enclosed space within the next 30 days.

Part of the actions includes no entry into the bin unless the material is four feet or less.

“A Vac truck and hose system will be used from outside the bin when materials are greater than four feet.”

The 100 Mile Free Press has contacted West Fraser but has not yet received a response.


newsroom@100milefreepress.net

Like us on Facebook and follow us on Twitter.

Just Posted

Jared Popma recently streamed a live concert from the Cowichan Performing Arts Centre. (Ashley Daniel Foot photo)
21-year-old jazz artist talks favourite tunes and joys of music theory

Jared Popma recently streamed a concert from the Cowichan Performing Arts Centre

Vetch cover crop beginning to flower. (Mary Lowther photo)
Mary Lowther column: Vetch and crimson clover to the rescue of soil fertility

I add dry organic fertilizer as plants use up what is in the soil.

Sarah Simpson
Sarah Simpson column: A shift in perspective can sometimes change everything

Have you even been forced to wake up at 5:30 on a Saturday

Black Press file photo
RCMP seek suspect in Vancouver Island-wide crime spree

Crimes stretched from Deep Bay to Qualicum, Ladysmith, Chemainus and Youbou

North Cowichan’s committee of the whole have rejected staff’s recommendation to limit the use of fireworks to Halloween. (File photo)
North Cowichan rejects limiting fireworks to Halloween

Municipality decides staff recommendation would be unpopular

Marco Mendicino, Minister of Immigration, Refugees and Citizenship during a press conference in Ottawa on Thursday, May 13, 2021. THE CANADIAN PRESS/Sean Kilpatrick
Canada to welcome 45,000 refugees this year, says immigration minister

Canada plans to increase persons admitted from 23,500 to 45,000 and expedite permanent residency applications

Emily Steele holds up a collage of her son, 16-year-old Elijah-Iain Beauregard who was stabbed and killed in June 2019, outside of Kelowna Law Courts on June 18. (Aaron Hemens/Capital News)
Kelowna woman who fatally stabbed teen facing up to 1.5 years of jail time

Her jail sentence would be followed by an additional one to 1.5 years of supervision

Cpl. Scott MacLeod and Police Service Dog Jago. Jago was killed in the line of duty on Thursday, June 17. (RCMP)
Abbotsford police, RCMP grieve 4-year-old service dog killed in line of duty

Jago killed by armed suspect during ‘high-risk’ incident in Alberta

Cannabis bought in British Columbia (Ashley Wadhwani/Black Press Media)
Is it time to start thinking about greener ways to package cannabis?

Packaging suppliers are still figuring eco-friendly and affordable packaging options that fit the mandates of Cannabis Regulations

The George Road wildfire near Lytton, B.C., has grown to 250 hectares. (BC Wildfire Service)
B.C. drone sighting halts helicopters fighting 250 hectares of wildfire

‘If a drone collides with firefighting aircraft the consequences could be deadly,’ says BC Wildfire Service

A dose of the Pfizer-BioNTech COVID-19 vaccine is pictured at a vaccination site in Vancouver Thursday, March 11, 2021. THE CANADIAN PRESS/Jonathan Hayward
NACI advice to mix vaccines gets varied reaction from AstraZeneca double-dosers

NACI recommends an mRNA vaccine for all Canadians receiving a second dose of a COVID-19 vaccine

A aerial view shows the debris going into Quesnel Lake caused by a tailings pond breach near the town of Likely, B.C., Tuesday, Aug. 5, 2014. THE CANADIAN PRESS/Jonathan Hayward
Updated tailings code after Mount Polley an improvement: B.C. mines auditor

British Columbia’s chief auditor of mines has found changes to the province’s requirements for tailings storage facilities

A North Vancouver man was arrested Friday and three police officers were injured after a 10-person broke out at English Bay on June 19, 2021. (Youtube/Screen grab)
Man arrested, 3 police injured during 10-person brawl at Vancouver beach

The arrest was captured on video by bystanders, many of whom heckled the officers as they struggled with the handcuffed man

Most Read